USS Scorpion Might Be the Greatest Tragedy In U.S. Navy History

April 16, 2021 Topic: Submarines Region: Americas Blog Brand: The Reboot Tags: SubmarinesMilitaryUSS ScorpionNuclear SubmarinesDisasters

USS Scorpion Might Be the Greatest Tragedy In U.S. Navy History

The loss of the USS Scorpion in 1968 sparked a mystery that tested the sleuthing skills of maritime experts.

Here's What You Need to Know: By 1968 it was obvious to the Navy’s Bureau of Ships that the submarine was badly in need of major overhaul.

Even in the age of ultra-sophisticated nuclear submarines, with their advanced computers, sonar, navigation, and communication systems, the hard truth is inescapable: the sea is the most hostile environment on Earth. It is totally unforgiving of human error or overconfidence. The pressures below 2,000 feet can crush a submarine like an aluminum can in seconds. For reasons that even now are a closely guarded secret, that happened in late May 1968 when the nuclear attack submarine USS Scorpion (SSN-589) sank in the middle of the Atlantic Ocean as she was returning from a long deployment. Ninety-nine officers and men were on board the Scorpion.

The Scorpion was third in the revolutionary new Skipjack class of nuclear fast-attack subs. She was commissioned at the Electric Boat Shipyard in Groton, Connecticut, on July 29, 1960. The rapidly changing Cold War arena demanded that each one of the U.S. Navy’s nuclear submarines be on continual service for the purpose of locating and tracking Soviet attack and missile submarines.  But time and constant service took their toll. The Navy was pushing the Scorpion to its limits; as a result, systems began to break down. There were serious oil leaks in the machinery, and sea water seeped in from the propeller shaft seal. Her depth was restricted to 300 feet, well above the 900-foot test depth. In 1967 she experienced vibration so severe it seemed that the entire boat was literally corkscrewing through the water. The cause was never determined. The crew had taken to calling their boat the “Scrapiron.”

By 1968 it was obvious to the Navy’s Bureau of Ships that the submarine was badly in need of major overhaul. Yet the demands of the Cold War made it necessary to send Scorpion and her officers and crew on one more deployment to the Mediterranean Sea to participate in joint NATO operations.

She would, however, sail with one less man. Electrician’s Mate Dan Rogers, who refused to go on the cruise, flatly stated to Lt. Cmdr. Francis Slattery that every man on Scorpion was in danger.

The crew, while enjoying the occasional liberty in Italy, Sicily, and Spain, grimly worked to keep their weary submarine operating until they reached Norfolk, Virginia, at the end of May. The Scorpion left Rota, Spain, on April 28 and headed west across the Atlantic on or about May 20. Slattery radioed on May 21 that their estimated time of arrival was 1 pm on May 27.

When the Scorpion did not arrive at her berth at the Norfolk Navy Yard on May 27, repeated calls of Scorpion’s call sign, Brandywine, went unanswered. Even before the fearful family members dejectedly returned home not knowing what had happened to their loved ones, the Navy’s situation room in the Pentagon was full of worried officers who were trying to determine why the submarine had gone missing. On the large Atlantic Ocean wall chart a line was drawn along the Great Circle route from Gibraltar to Norfolk. Somewhere along that 3,300-mile arc the Scorpion and her crew could be struggling to survive a serious mechanical casualty. Or she could be down, a word that had grim implications to the submarine service. In any event she had to be found. One thing was reasonably certain: the Soviets had nothing to do with the disappearance.

This is where Dr. John Craven, the chief civilian scientist of the special projects division and a skilled engineer, entered the picture. Craven, whose work had made him a legend in the Navy, had been instrumental in finding the lost H-bomb that had fallen into the sea off Spain when a B-52 collided with a KC-97 tanker. He had used a revolutionary method of calculating poker odds and mathematics to determine the probable location of the bomb. Despite universal scorn at his methods, Craven had led the Navy right to the missing weapon. He had been on the team that designed the Polaris missile launching system. Craven was not above unusual ideas. Upon hearing of Scorpion’s failure to arrive at Norfolk, he entered the situation room to see the grim faces staring at the vast Atlantic Ocean chart. He offered to help. Having few options, the Navy accepted his offer. The alternative was a protracted and probably futile air-sea search.

Craven knew that the newly operational sonar surveillance system would be of little help on this search. The system’s array on the sea floor filtered out all noise except that of machinery such as what was used on Soviet subs. He began by examining the readouts of underwater hydrophones located in the Canary Islands and Newfoundland. By linking the time scale of the two readouts, Craven and Naval Research Laboratory acoustic engineer Wilton Hardy found a suspicious series of five to eight underwater explosions around the time Scorpion would have been in the mid-Atlantic. The depth of the water was 11,000 feet, far deeper than any military submarine could survive. “How the hell are we going to find these poor bastards?” Craven wondered.

Chief of Naval Operations Admiral Thomas Moorer appointed Craven to head a technical advisory group. The group used estimates of Scorpion’s speed and course, comparing them to the acoustic anomalies found on the hydrophone readouts. Sure enough, all of them fell right on the submarine’s track.

First, there was a single bang, followed 90 seconds later by more underwater rumbles that could only be the fatal sounds of a submarine’s compartments imploding under immense pressure. It took only three minutes and 12 seconds. Then all was quiet. Craven contacted Moorer to inform him that Scorpionwas probably lost. Moorer waited until some word had come in from the search ships and planes. But nothing was found. On June 5, the Navy announced that Scorpion and her crew were presumed lost. At that point, the Navy had to find and examine the wreck. Using the oceanographic research vessel Mizar, a systematic search of the sea floor with towed camera sleds failed to find the wreck west of the point where the first explosion had occurred. This made no sense.

Then Craven’s team noted one odd discrepancy. At the moment of the first explosion, Scorpion had not been headed west, but east. What would make a submarine suddenly change course 180 degrees? Craven asked experienced submarine commanders and in every case he was told the same answer: a so-called hot run torpedo. When a torpedo activates onboard a submarine, it is called a hot running torpedo, which is highly dangerous. A submarine skipper’s immediate response to the warning of a hot run is to order a 180-degree turn. This triggers a fail-safe device in the torpedo that shuts down the warhead.

If Scorpion had experienced a hot run torpedo while on the return voyage to Norfolk, Slattery would automatically have ordered an emergency hard left rudder to turn the boat around as fast as possible. According to the skippers Craven queried, this was drilled into every officer who conned a submarine. The Scorpion had recovered from a hot run torpedo in December 1967, and Slattery had performed exactly that maneuver. This scenario would put the wreckage east, not west of the coordinates of the initial explosion. Few officers gave this theory any credence, but Craven persisted. On October 29, Mizar found the shattered remains of Scorpion right where Craven’s team said it would be. The hull was torn apart by violent forces, the stern was telescoped into the engine room, and the bow was smashed back toward the sail. The entire underside was ripped away. Scattered bits and pieces littered the sea floor like leaves after a storm. There was no doubt—the 99 crew members were dead.

What had happened? Was the submarine sunk by her own torpedo? Like all Cold War subs, Scorpion carried warshots, that is, live torpedoes. She carried 14 Mark 37 electric torpedoes, seven steam-powered Mark 14s, and two nuclear-tipped Mark 45s. It was common practice on an American submarine to perform maintenance on all of the submarine’s equipment and weapons at the end of a patrol. With this in mind, Craven began investigating the possibility that one of Scorpion’s torpedoes had activated during a maintenance check. One of Craven’s favorite maxims was that if a piece of equipment can be installed backward, it will be. Sure enough, he discovered that there had been several instances of torpedoes being activated while undergoing routine electronic maintenance because some of the testing units had transposed wiring. It seemed more and more likely that one of Scorpion’s torpedoes had exploded inside the hull. Craven was personally convinced, but he found no acolytes among the Navy brass.

The Ordnance Systems Command (OSC), the department that oversaw the development and operation of every weapon in the Navy’s inventory, steadfastly insisted that it was impossible for a sub’s torpedoes to explode inside the hull; however, OSC did not deny that hot runs did occur. Understandably, the Navy was not anxious to accept the grim possibility that one of its boats and its crew had been killed by its own torpedo. Even more unnerving was the chance that every one of the submarine force’s torpedoes was flawed. This is the official mindset Craven faced in the fall of 1968.